Loading...
HomeMy WebLinkAbout5.a. Danner ME Renewal 2021 EXECUTIVE SUMMARY Planning Commission Regular Meeting: December 14, 2020 Tentative City Council Meeting: January 19, 2021 AGENDA ITEM: Case 20-55-ME Renewal of the Danner, Inc. Small Scale Mineral Extraction Permit for 2021. AGENDA SECTION: Public Hearing PREPARED BY: Kyle Klatt, Senior Planner AGENDA NO. 5.a. ATTACHMENTS: Location Map, Draft 2021 Mineral Extraction Permit, Letter from Applicant, Mineral Extraction Status Map, Topographic Map, Fill Area Grading Plan (2017), Site Photos, Aerial Images APPROVED BY: KL RECOMMENDED ACTION: Motion to recommend the City Council renew the Danner, Inc. Small Scale Mineral Extraction Permit for 2021, subject to the terms and conditions in the attached Draft 2021 Conditions for Mineral Extraction. SUMMARY The Planning Commission is being asked to consider an application from Danner, Inc. requesting renewal of their annual small-scale mineral extraction permit for the 2021 calendar year. The small- scale mineral extraction operation is located at 4594 145th Street East in the eastern portion of the City. Small Scale Mineral Extraction is permitted in the City as an Interim Use within specified areas, and the permit for such uses expires after one year. The Danner site has been operating as a mine for several years, and the request for renewal is consistent with similar renewals that have previously been issued for the site. Applicant & Property Owner(s): Marlon L. Danner of Danner, Inc. Location: 4594 145th Street East – one half mile east of US Highway 52 and one quarter mile south of CSAH 42 Area: 75 Acres Comp. Guide Plan Designation: LDR Low Density Residential; MDR – Medium Density Residential; HDR – High Density Residential Current Zoning: AG – Agriculture The applicant, Marlon Danner of Danner, Inc., requests renewal of the existing Small-Scale Mineral Extraction permit for 2021. Staff is not aware of any significant issues associated with site mining and haul-back since the last review. Please note that the approved permit allows the applicant to perform grading work in the northern portion of the site, outside of the approved mining area. While this work is acceptable under the terms of the permit, the applicant should ensure there is adequate fill and topsoil remaining for reclamation of the mining site. After requesting a modification to the phasing of the grading work that was ultimately approved by the City, the work commenced three years ago and has been part of the ongoing mining and reclamation operation being conducted on the site. All such grading is taking place in the “Phase 1” grading area adjacent 2 to County Road 42. It does not appear that much, if any, additional material was placed in the phase 1 fill area in 2020. The overall status map has been updated to identify the active grading area on the subject property. Staff recommends approval of the request based upon a review of the information submitted by the applicant, the mineral extraction standards in Section 11-10-4 of the City Code, City Police records and the attached permit. BACKGROUND Based on recent permit renewals and a discussion with the applicant, the Danner operation extracted approximately 40,000 tons of sand and gravel in 2014, and approximately 65,000 tons of material for each year from 2015 through 2017. For 2018 and 2019, the applicant reported the extraction of 60,000 tons of material (please note that applicant’s dates appear to be off by a year in the application narrative), and this was the case for 2020 as well. The applicant has noted that they expect to extract the same amount of material in 2021 as it has in each of the last three to four years, with the possibility of removing slightly more depending on market conditions. In addition to the excavation activity, Danner continues to import material to the site for future reclamation. Over the past year, the applicant reports that there were 5,000 cubic yards of “haul- back” material brought to the site from a combination of local government road improvement projects and other redevelopment projects in the area. Testing of this material has not been performed since 2018; at that time the annual review included a report describing the testing performed by Braun Intertec on this haul-back material in late 2016 and early 2017. Braun Intertec’s testing found that the soils “meet the requirements of the 2014 Conditions for Small Scale Mineral Extraction Permit for Danner and the Borrow Pit Reclamation Protocol, along with complying with the MPCA guidance for Best Management Practices for the Off-Site reuse of Unregulated Fill.” The material brought to the site over the past few years originated in the same stockpiles from Danner’s South St. Paul yard. Given the relatively small amount of material brought to the site over the past two years, staff does not believe it is critical to complete testing each year but is recommending a condition as part of next year’s permit that will require haul-back material testing and reporting to be completed in early 2021. Staff has previously asked that the haul-back from the last two years, and any in the first part of 2021 be maintained in one location so that testing of all material can occur. The site plans submitted with the renewal request (which were last updated in February of 2019) indicate that active mining is continuing in the southerly portions of Phases One and Two of the overall site. Based upon the plan and site inspection, stockpiling is occurring in the northern portion of Phase One and Two or areas designated for future phases. The submitted drawing illustrates the area outlined in blue is a combination of stockpiling, circulation, and material handling activity. This work area is greater than just the mining function. 3 The application previously stated that little restoration is occurring on the site due to stockpiling of material. As part of most recent permit renewal, staff recommended that some restoration work be completed in 2020. The project narrative indicates that some filling has been occurring on the southern property line, and the updated aerial image for the property does show that there has been additional restoration completed in the southeast corner of the mine. In general, the City expects reclamation to occur as mining reaches the approved elevations, and staff is recommending that this restoration continue in 2020 and the lowest mining elevation is reached further to the west. The applicant is starting to run out of room for excavation in the first two phases and will need to complete additional restoration work in these phases before moving into the third phase. It is expected substantial restoration occur in 2020 to permit further mining of the site. An updated topographic survey was submitted in early 2019 and is included in the review materials for the Planning Commission. The updated survey notes that the lowest elevation of the mine is at 840.3 feet and above the lowest elevation allowed in the permit. Because Danner has not been removing a significant amount of material, staff has not required the applicant to update the mining plan each year; however, the current drawing is nearing two years old and should be updated before the end of 2021. During the previous reviews, staff noted that there was storage taking place on the property unrelated to the mining activity. The permit was therefore updated in 2017 to limit the number of storage trailers allowed on the property. Based on staff’s site visit in October of 2020 and evidence from recent air photographs of the site, the applicant is following the requirement. Grading work is expected to continue throughout 2021 and must adhere to the approved grading plan (as updated to reflect the revised phasing plan). The intent of the grading is to create a level site with access from County Road 42 for future development. It is staff’s understanding that some of the material is from the mining site. The property/ owner will be expected to fulfill the reclamation plans using additional on-site material or bring additional topsoil etc. from off site. ISSUE ANALYSIS Aggregate mining is reviewed through an interim use permit which is Quasi-Judicial actions. As such, the City has a set of standards and requirements for review. Generally, if the applications meet the ordinance requirements they must be approved. The standards and requirements for this mineral extraction are detailed in Section 11-10-4 of the Zoning Ordinance and the attached Mineral Extraction permit. The subject property is zoned AG – Agriculture and meets or exceeds the applicable performance standards for small scale mineral extraction. Small scale mineral extraction is listed as an interim use within the Agriculture district. The table below details the current land use, zoning, and future land use information for the surrounding properties. These properties are all currently zoned Agricultural or Agricultural Preserve and are located within the 2030 or 2040 Metropolitan Urban Service Area (MUSA). The 2040 Future Land Use Map anticipates a mixture of residential and business park uses in this area. 4 Surrounding Land Use and Zoning Information Direction Current Land Use Zoning Guided Land Use North Agriculture Agricultural BP – Business Park South Agriculture Agricultural Preserve LDR – Low Density Residential East Agriculture Agricultural LDR – Low Density Residential and MDR – Medium Density Residential West Agriculture/Mining Agricultural LDR – Low Density Residential and MDR – Medium Density Residential Access to the Danner mine comes from County Road 42 via a gravel road along the eastern edge of the property. This road is shared with the Bolander mine to the west. The applicant maintains a private access agreement with the neighboring property to coordinate mining levels and allow continued access to both the sites. The permit application notes that haul roads within the City will continue to be County Road 42 to State Highway 52. The annual renewal for mineral extraction permits includes a site inspection and consultation with the Rosemount Police Department regarding any police activity. Police records noted no activity at (or calls to) the subject property in 2020. Staff has drafted an updated permit for review by the Planning Commission as part of its review. RECOMMENDATION Staff recommends approval of this request based upon a review of the information submitted by the applicant, the mineral extraction standards in Section 11-10-4 of the City Code, City Police records and the attached draft permit. Danner Mine Property Information 0 1,750 3,500875 ft 0 525 1,050262.5 m 1:19,200 Disclaimer: Map and parcel data are believed to be accurate, but accuracy is not guaranteed. This is not a legal document and should not be substituted for a title search,appraisal, survey, or for zoning verification. 1 Mineral Extraction Permit 2021 Conditions for Small Scale Mineral Extraction Permit DANNER, INC. A Danner Inc., hereinafter referred to as the “Property Owner”, shall sign a written consent to these conditions binding itself and its successors or assigns to the conditions of said permit. B The property Owner shall comply with all terms of this permit as well as the standards for mineral extraction listed in Section 11-10-04 of the City Code. C This permit is granted for the area designated as the eastern half of Phase Two and the entire Phase One (approximately 19.5 acres) on Exhibit A, Mineral Extraction Permit Status Map, which is attached hereto as an exhibit. Regrading and reclamation is granted for the area designated Phase I on Exhibit A. Mineral Extraction Permit dated 10-24-2016. Reclamation in Phase I should occur over the 2021 calendar year. D The term of the permit shall extend from the date approved by the City Council until December 31, 2021 unless revoked prior to that for failure to comply with the permit requirements. An Annual Mining Permit fee shall be paid to the City of Rosemount. E All required permits from the State of Minnesota, County of Dakota and City of Rosemount (hereinafter "City") or any of their agencies shall be obtained and submitted to the City prior to the issuance of the permit. Failure by the Property Owner to comply with the terms and conditions of any of the permits required under this paragraph shall be grounds for the City to terminate said mining permit. F The final grading for the permit area shall be completed in accordance with the Final Reclamation Plan, attached as Exhibit B, or as approved by the City Engineer, and any other conditions that may be imposed by the City from time to time. G All gravel trucks and other mining related traffic shall enter and exit the mining area from County State Aid Highway 42. It shall be the Property Owner's responsibility to obtain any access permits or easements necessary for ingress and egress. The location of the accesses and/or easements for ingress and egress shall be subject to approval by the City, as well as the County Highway Department if any changes occur relative to the mining process. H A plan for dust control shall be implemented and subject to approval by the City. The Property Owner shall clean dirt and debris from extraction or hauling operations related to the Mineral Extraction Permit from streets. After the Property Owner has received 24-hour verbal notice, the City may complete or contract to complete the clean-up at the Property Owner’s expense. In the event of a traffic hazard as determined by the Public Works Director or Rosemount Police Department, the City may proceed immediately to complete or contract cleanup at Property Owner’s expense without prior notification. I The surface water drainage of the mining area shall not be altered so as to interfere, contaminate, or otherwise affect the natural drainage of adjacent property. J No topsoil shall be removed from the site and the Property Owner shall take necessary measures to prevent erosion of the stockpiled topsoil. The location of the stockpiled topsoil shall be as indicated on Exhibit A. K Any costs incurred now or in the future in changing the location of existing public or private utilities including but not limited to pipelines, transmission structures and sewer infrastructure located within the permit area shall be the sole obligation and expense of the Property Owner. 2 L All costs of processing the permit, including but not limited to planning fees, engineering fees and legal fees, shall be paid by the Property Owner prior to the issuance of the permit. The Property Owner shall reimburse the City for the cost of periodic inspections by the City Engineer or any other City employee for the purpose of insuring that conditions of the permit are being satisfied. The Property Owner agrees to reimburse the City for any other costs incurred as a result of the granting or enforcing of the permit. M The daily hours of operation for the mining area shall be limited to 7:00 a.m. to 7:00 p.m. Monday through Saturday, subject, however, to being changed by the City Council. N The Property Owner shall deposit with the Planning Department a surety bond or cash escrow in the amount of Seven Thousand Five Hundred Dollars per acre ($7,500.00/acre) of active phase in favor of the City for the cost of restoration, regrading and/or revegetating land disturbed by mining activities and to assure compliance with these conditions by the Property Owner. The required surety bonds must be: (1) With good and sufficient surety by a surety company authorized to do business in the State of Minnesota with the right of the surety company to cancel the same only upon at least thirty (30) days written notice to the permit holder and the City. (2) Satisfactory to the City Attorney in form and substance. (3) Conditioned that the Property Owner will faithfully comply with all the terms, conditions and requirements of the permit; all rules, regulations and requirements pursuant to the permit and as required by the City and all reasonable requirements of the City Engineer, or any other City officials. (4) Conditioned that the Property Owner will secure the City and its officers harmless against any and all claims, or for which the City, the Council or any City officer may be made liable by reason of any accident or injury to persons or property through the fault of the Property Owner. (5) The surety bond or cash escrow shall remain in effect from January 1, 2021 to July 31, 2022. Upon thirty (30) days’ notice to the permit holder and surety company, the City may reduce or increase the amount of the bond or cash escrow during the term of this permit in order to insure that the City is adequately protected. O. The Property Owner shall furnish a certificate of comprehensive general liability insurance issued by insurers duly licensed within the State of Minnesota in an amount of at least Five Hundred Thousand and no/100 ($500,000.00) Dollars for injury or death of any one person in any one occurrence, bodily injury liability in an amount of at least One Million Five Hundred Thousand and no/100 ($1,500,000.00) Dollars and property damage liability in an amount of at least Two Hundred Fifty Thousand and no/100 ($250,000.00) Dollars arising out of any one occurrence. The policy of insurance shall name the City as an additional insured and shall remain in effect from January 1, 2020 to July 31, 2021. P. The storage of equipment (unrelated to the sand and gravel mining and processing), manure, construction debris, or hazardous materials of any kind shall not be permitted on site. The placement of construction debris, manure, asphalt in any form or hazardous materials within the pit as fill shall be strictly prohibited. Q. The Property Owner shall hold the City harmless from all claims or causes of action that may result from the granting of the permit. The Property Owner shall indemnify the City for all costs, damages or expenses, including but not limited to attorney's fees that the City may pay or incur in consequence of such claims. R. The Property Owner shall comply with such other requirements of the City Council as it shall from time to time deem proper and necessary for the protection of the citizens and general welfare of the community. S. Complete mining and reclamation is required in all phases before any additional mining is authorized. Modifications or expansion of the mining areas must be approved in writing to the City. Property Owner shall submit to the City semiannually a written report indicating the amount of material extracted from the site for the prior six-month period. 3 T. The Property Owner shall incorporate best management practices for controlling erosion and storm water runoff as specified by the Minnesota Pollution Control Agency and the United States Environmental Protection Agency. U. Reclamation shall include the replacement of the entire stockpile of topsoil on the mined area, reseeding and mulching necessary to re-establish vegetative cover for permanent slope stabilization and erosion control. The minimum depth of topsoil shall not be less than two inches after reclamation. No restored slopes may exceed a gradient of 25% or four to 1 (4:1). V. The Property Owner must show how materials stockpiled for recycling will be processed and inform the City of all stockpiled materials. W. All recycling must be completed with the completion of the current phase and materials removed from the site. No recycling processes shall be allowed to continue into subsequent phases. X. The Property Owner may not assign this permit without written approval of the City. The Property Owner will be responsible for all requirements of this permit and all City ordinances on the licensed premises for the permit period unless the Property Owner gives sixty (60) days prior written notice to the City of termination and surrenders the permit to the City. The Property Owner shall identify all Operators prior to their commencement of mineral extraction-related activities in the pit area. The City shall have the authority to cause all mineral extraction activities to cease at any time there is an apparent breach of the terms of this Permit. Y. The Property Owner shall install and maintain a “stock” gate (or equivalent) at the entrance to the property where the mining operation is located. The gate must be secured at 7:00 p.m. and at any time the pit is not in use. Z. The fill area regrading and reclamation shall follow the procedures described in the Danner Inc. Borrow Pit Reclamation Protocol Rosemount, Minnesota including a report submitted to the City describing the quantities of material brought in, where the material came from, and the test result of the material. The reports submitted shall describe the quantities of material brought in, where the material came from, and the test results, including supporting analytical results of the materials. AA. No gravel mining is permitted in the Fill Area as shown on Exhibit A. BB. Mining to the elevation of 840 feet above mean sea level provided that the site is reclaimed to the elevation shown on Exhibit A with haul-back, clean-fill material in accordance with the Danner Inc. Borrow Pit Reclamation Protocol Rosemount, Minnesota. In no instance shall mining occur in the groundwater aquifer. CC. Blasting or the use of explosives is prohibited in the mining of the Danner gravel pit. DD. The City of Rosemount shall have the ability to collect independent soil and water samples. EE. The operator shall install and maintain “No Trespassing” signs consistent with the standards outlined in Minnesota State Statute 609.605. FF. The operator is permitted to have two trailers for storage of items directly related to the operation of the mine and mining equipment. Storage of more than two trailers would be a violation of the conditions of the mining permit and could be cause for revocation of the approval. 4 That Danner, Inc., Property Owner, hereby consents and agrees to the foregoing conditions of said mining permit. IN WITNESS WHEREOF, the Property Owner has hereunto set his hand this _____ day of __________________, 20_____. DANNER, INC. By:__________________________________ Its: _________________________ STATE OF MINNESOTA ) ) § COUNTY OF __________ ) The foregoing instrument was acknowledged before me this ______day of _________________, 20___, by __________________________________, on behalf of Danner, Inc., Property Owner. ______________________________________ Notary Public 107221 PIT STATUS 2017 LANDSCAPE ARCHITECTS I hereby certify that this plan was prepared by me or under my direct supervision and that I am a duly Licensed Professional Engineer under the laws of the State of 2422 Enterprise Drive,Mendota Heights, MN 55120 (651)681-1914 Fax:681-9488 CIVIL ENGINEERS LAND PLANNERS LAND SURVEYORS Date Designed Drawn Name Reg. No. Date OF 10-24-16 NAP NAP 11DANNER, INC. SOUTH ST. PAUL, MINNESOTA 55075 ROSEMOUNT PIT - CO. RD. 42 ROSEMOUNT, MINNESOTA MINERAL EXTRACTION PERMIT 843 HARDMAN AVENUE SOUTH 2018 - STATUS LOCATION MAP LOWEST VERIFIED ELEVATION: 840.3 12-17-18 LicenseState Danner Mine Inspection November 2020 Active Mining Area Material Stockpiles Danner Mine Inspection October 2019 Material Stockpiles Entrance Road Danner Aerial Images September 2020 September 2019